Installed Piping System
Installed Piping System on 9/25/2023. Transferred 22 gallons of 100% glycol to first 30/70 drum add water to 30/70 mixture. Add water to the 38 gallons. Fill tank turn pump on. Fill tank adjusting level to not overflow tank when pump shuts off. Finished bleeding the system adjusting new glycol levels. Adjust set point watch […]
Replaced The Contactor Cut Off Burnt Pieces of Wire
Replaced the contactor, cut off burnt pieces of wire and re connected turned unit on and verified proper function on 9/22/2023 in Plano Texas. Near W Park Blvd Plano, Texas 75093 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.prorefrigerationone.com/areas-we-serve/ [spacer]
Pick up New Sensor, Remove Old Sensor, Install New Sensor
Pick up new sensor, remove old sensor, install new sensor and confirm all systems are functioning on 9/18/2023 in Sachse Texas. Near The Station Boulevard Sachse, Texas 75048 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.prorefrigerationone.com/areas-we-serve/ [spacer]
Penetrative Maintenance done on All Equipment
Penetrative Maintenance done on all equipment on 9/14/2023. All of the small units were clean and at temp with. No seen issues. The WIC evaporator coil is a little dirty but nothing to be too concerned about this trip out. The WIC condenser had a clean coil and was running very well. The WIF evaporator […]
I Could Actually Feel The Leak
I could actually feel the leak as I peeled back the plastic covering. I replaced the entire section of pipe with 1/4 soft copper tubing and added service port. I also replaced the spin copper drier. I pulled a deep vacuum and recharged the system with fresh r290. System can be returned to service after […]
Washed Condenser and Straightened Coil Fins
Washed condenser and straightened coil fins on 9/12/2023. Also tightened vent a hood belt and lubed bearings in Carrollton Texas. Near Old Denton Road Carrollton, Texas 75007 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.prorefrigerationone.com/areas-we-serve/ [spacer]
Checked Two Glass Freezer and Controller
Checked two glass freezer and controller tends to fluctuate temp and client asked if could set to 4°F so I replaced Ranco controller with adjustable temp mechanical controller in Farmers Branch Texas. Near Medical Pkwy Farmers Branch, Texas 75234 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.prorefrigerationone.com/areas-we-serve/ [spacer]
Found the water valve faulty
Found the water valve faulty and the water pump faulty on 8/31/2023 and I replaced both parts and verified harvest of ice three times in Addison Texas. Near Addison Cir Addison, Texas 75001 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.prorefrigerationone.com/areas-we-serve/ [spacer]