mounted new sensor
4/28/2023 Replaced temperature probes, took out old probes, removed the evaporator cover and mounted new sensor. All operation verified in Dallas Texas. Near Victory Park Lane Dallas, Texas 75219 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.prorefrigerationone.com/areas-we-serve/ [spacer]
replaced the dump valve
On 4/27/2023 found the unit was draining all the time, I replaced the dump valve and found pieces of plastic stuck inside the valve, once replaced I watched the unit dump 3 batches of ice and verified all proper operations. No further issues found in Kennedale Texas. Near West Kennedale Parkway Kennedale, Texas 76060 Check […]
High Pressure Switch was Leaking
On 4/26/2023 found unit has the sanitize light on, i ran the unit through its clean cycle to get the light off, once the clean light was off i tested all other proper operations, found the unit had a leak on the discharge side, the high pressure switch was leaking and found the water level […]
Cleaned the Dirty Condenser Coil
On 4/24/2023 Upon arrival I found unit completely empty, I found the coil frozen up and cleaned the dirty condenser coil. I ran the unit through defrost a couple times to clear off ice, once cleared I tested units heaters along with the time of defrost, unit was left open and caused evaporator to freeze […]
Schrader Core on the Discharge was Leaking
On 4/20/2023 Upon arrival I found the unit at 55 degrees, I found the unit was low on refrigerant, causing the issues, upon further investigation I found the Schrader core on the discharge was leaking. I replaced the core and installed a steel cap to ensure no further leaks will occur on the said line. […]
Found the Walk In Cooler Over Charged
On 4/18/2023 Found the walk in cooler over charged. The walk in freezer needs a liquid line filter drier, checked all operations, no further issues found. Wic is working as it should in Red Oak Texas. Near South Main Street Red Oak, Texas 75154 Check out the Areas We Serve and jobs we are doing […]
Wire on Main Terminal Block Had Been Loose
On 4/17/2023 found the #1 wire on main terminal block had been loose causing the power issue with the unit, i tightened the terminal blocks wire and restored power to the fans and compressor, watched unit cycle on the thermostat with no further issues found at this time in Plano Texas. Near Tennyson Parkway Plano, […]
Removed Compressor and Sweat in New Compressor
On 4/12/2023 Recovered refrigerant, disconnected power, removed compressor and sweat in new compressor, changed filter drier, pulled 500-micron vacuum, charged system with refrigerant, reconnected power and started up unit. Confirmed proper function in Fairview Texas. Near Country Club Road Fairview, Texas 75002 Check out the Areas We Serve and jobs we are doing by clicking […]
Replaced the Filters on the Roof
On 4/10/2023 replaced the filters on the roof with the ones that were onsite, once replaced i checked all proper operations of the units, rtu 1 and 2. Both units inspected, no issues found in McKinney Texas. Near Eldorado Parkway McKinney Texas 75070 Check out the Areas We Serve and jobs we are doing by […]
Installed Condenser Motors
On 4/6/2023 Removed old condenser motors. Had a difficult time getting the back fan out due to lack of space. Installed condenser motors. Checked operation. Unit is now making ice. Installed new controller for reach in cooler in Royse City Texas. Near FM2453 Royse City, Texas 75189 Check out the Areas We Serve and jobs […]